Micr oPo MicroP ow wer er Dir Direct ect ADB05, ADB1 0, ADB1 6 ADB10, ADB16 Series Miniature, High Performance AC/DC Power Supplies Electrical Specifications Input Parameter C ondi ti ons Mi n. Typ. Max. Uni ts Input Voltage Range See Note 1 90 264 VAC Input Frequency See Note 1 47 63 Hz Input C urrent See Model Selecti on Gui des Inrush C urrent EMI 115 VAC 14.1 230 VAC 32.5 A Pk 115 VAC 0.5 230 VAC 3.5 mA Output Parameter C ondi ti ons Mi n. Typ. Output Voltage See Model Selecti on Gui des Output C urrent See Model Selecti on Gui des Output Voltage Accuracy "2.0 See Note 2 Li ne Regulati on See Model Selecti on Gui des Load Regulati on See Model Selecti on Gui des Noi se & Ri pple 115 VAC 20 230 VAC 80 See Note 4 Temperature C oeffi eci ent Over Voltage Protecti on Short C i rcui t Protecti on Overload Protecti on 116 124 Uni ts % P k- P k mSec. 3 mSec 132 % Vout %/1C 0.02 Pri mary Output ! Low Leakage Current ! LOW LOW COST % 1.0 Hold-Up Ti me Transi ent Response Max. ! 3,000VAC Isolation ! Universal Input Range ! Full Safety Approvals ! Single,Dual & Triple Outputs ! Miniature Packaging ! Wide Operating Temp Meets C ISPR PUB. 22/FC C C lass B Safety Ground Leakage C urrent Key Features: Power Foldback, Self-Recoveri ng Typ. 130% of Output Power, Foldback Type General Parameter C ondi ti ons Effi ci ency Isolati on Voltage Mi n. Max. Uni ts See Model Selecti on Gui des Input to Output 3,000 Input to Ground 1,500 Output to Ground Swi tchi ng Frequency Typ. VAC 500 See Note 5 75 kHz Environmental Parameter C ondi ti ons Operati ng Temperature Range Storage Temperature Range C ooli ng Humi di ty Mi n. Typ. Max. Uni ts -0 +50 1C -40 +85 1C Free Ai r C onvecti on (see derati ng curve) RH, Non-condensi ng 95 Physical C ase Si ze C ase Materi al See Mechani cal C onfi gurati ons (Page 4) % Micr oP ower Dir ect C MicroP oPo Direct ect,, LL LLC 171 Tosca Drive Stoughton, MA 02072 USA Tel: (781) 344 - 8226 FAX: (781) 344 - 8481 ! sales@micropowerdirect.com " www.micropowerdirect.com Impact Resi stant, Non-C onducti ve Black Plasti c Specifications typical @ +251C with nominal input voltage &rated output current, unless otherwise noted. Specifications subject to change without notice. Micr oP ower Dir ect MicroP oPo Direct Model Selection Guide, ADB05 Series Model Number Input Current Output One (Vout 1) Output Tw o (Vout 2) Voltage Current Regulation Line L o ad Efficiency 115 VAC 230 VAC Voltage Current A D B 05S 03 0.15A 0.07A 3.3 VDC 1.33A "0.1% "1.0% 65% A D B 05S 05 0.15A 0.07A 5.0 VDC 1.00A "0.1% "1.0% 65% A D B 05S 12 0.15A 0.07A 12.0 VDC 0.45A "0.1% "1.0% 67% A D B 05S 15 0.15A 0.07A 15.0 VDC 0.36A "0.1% "1.0% 67% A D B 05D 05 0.15A 0.07A +5.0 VDC +0.50A -5.0 VDC -0.50A "0.5% "2.0% 65% A D B 05D 12 0.15A 0.07A +12.0 VDC +0.23A -12.0 VDC -0.23A "0.5% "2.0% 67% A D B 05D 15 0.15A 0.07A +15.0 VDC +0.18A -15.0 VDC -0.18A "0.5% "2.0% 67% Model Selection Guide, ADB10 Series Model Number Input Current Output One (Vout 1) Output Tw o (Vout 2) Output Three (Vout 3) Voltage Voltage Regulation Efficiency Line L o ad 2.40A "0.1% "1.0% 70% 2.00A "0.1% "1.0% 70% 0.83A "0.1% "1.0% 70% 0.70A "0.1% "1.0% 70% 24.0 VDC 0.45A "0.1% "1.0% 70% 48.0 VDC 0.25A "0.1% "1.0% 70% -1.00A "0.2% "2.0% 70% -12.0 VDC -0.45A "0.2% "2.0% 70% -15.0 VDC -0.35A "0.2% "2.0% 70% +1.00A +5.0 VDC +0.40A -5.0 VDC -0.40A "0.5% +3.3 VDC +1.00A +12.0 VDC +0.25A -12.0 VDC -0.25A "0.5% 0.13A +5.0 VDC +1.00A +12.0 VDC +0.25A -12.0 VDC -0.25A "0.5% 0.13A +5.0 VDC +1.00A +15.0 VDC +0.20A -15.0 VDC -0.20A "0.5% 115 VAC 230 VAC Voltage Current A D B 10S 03 0.3A 0.13A 3.3 VDC A D B 10S 05 0.3A 0.13A 5.0 VDC A D B 10S 12 0.3A 0.13A 12.0 VDC A D B 10S 15 0.3A 0.13A 15.0 VDC A D B 10S 24 0.3A 0.13A A D B 10S 48 0.3A 0.13A A D B 10D 05 0.3A 0.13A +5.0 VDC +1.00A -5.0 VDC A D B 10D 12 0.3A 0.13A +12.0 VDC +0.45A A D B 10D 15 0.3A 0.13A +15.0 VDC +0.35A ADB10T305 0.3A 0.13A +3.3 VDC ADB10T312 0.3A 0.13A ADB10T512 0.3A ADB10T515 0.3A Current Current 73% S ee Note 3 73% 73% 73% Model Selection Guide, ADB16 Series Model Number Input Current Output One (Vout 1) Output Tw o (Vout 2) Output Three (Vout 3) Voltage Voltage Regulation Efficiency Line L o ad 3.70A "0.1% "1.0% 73% 5.0 VDC 3.00A "0.1% "1.0% 73% 12.0 VDC 1.35A "0.1% "1.0% 73% 15.0 VDC 1.10A "0.1% "1.0% 73% 0.16A 24.0 VDC 0.70A "0.1% "1.0% 73% 115 VAC 230 VAC Voltage Current A D B 16S 03 0.33A 0.16A 3.3 VDC A D B 16S 05 0.33A 0.16A A D B 16S 12 0.33A 0.16A A D B 16S 15 0.33A 0.16A A D B 16S 24 0.33A Current Current A D B 16S 48 0.33A 0.16A 48.0 VDC 0.35A "0.1% "1.0% 73% A D B 16D 05 0.33A 0.16A +5.0 VDC +1.50A -5.0 VDC -1.50A "0.5% "2.0% 75% A D B 16D 12 0.33A 0.16A +12.0 VDC +0.68A -12.0 VDC -0.68A "0.5% "2.0% 75% A D B 16D 15 0.33A 0.16A +15.0 VDC +0.55A -15.0 VDC -0.55A "0.5% "2.0% 75% ADB16T305 0.33A 0.16A +3.3 VDC +1.80A +5.0 VDC +0.75A -5.0 VDC -0.75A "0.5% ADB16T312 0.33A 0.16A +3.3 VDC +1.80A +12.0 VDC +0.30A -12.0 VDC -0.30A "0.5% ADB16T512 0.33A 0.16A +5.0 VDC +1.80A +12.0 VDC +0.30A -12.0 VDC -0.30A "0.5% ADB16T515 0.33A 0.16A +5.0 VDC +1.80A +15.0 VDC +0.24A -15.0 VDC -0.24A "0.5% 73% See Note 3 73% 73% 73% 171 Tosca Drive Stoughton, MA 02072 ! TEL: (781) 344-8226 ! FAX: (781) 344-8481 ! E-Mail: sales@micropowerdirect.com #! WEB: www/micropowerdirect.com Remote ON/OFF (ADB16 Only) Specification Notes 1. All models will also operate off a DC input of 110 VDC to 340 VDC. 2. The primary output (Vout1) is adjustable by approximately -10% to +15%. The adjustment pot is located on the top of the unit. 3. Load regulation for ADB10 and ADB16 triple output models is "2.0% for Vout 1 and Vout 3. Load regulation for Vout 2 is "5.0%. Load regulation for all models is measured with the output under test undergoing a load step change of 100% to 50% at nominal input and all other outputs at 50% load. 4. Transient response is measured for the output returning to within specification within 3 mS following a 50% load change. 5. The switching frequency of the ADB16 series is 83 kHz. 6. It is recommended that an external 1A/250 VAC fuse be connected to the input line. Parameter Min Max. Units Supply ON 2.5 7.0 or Open VDC Supply OFF Short or 0.0 0.8 VDC TTL/CMOS Compatible Input Referenced to DC Gnd All ADB05/10/16 models are specified for operation over the wide operating temp range of 01C to +501C without derating. For operation over +501C, without moving air, derate the output power linearly 2.5%/1C to 50% output power at +711C. For operation below 01C, see the derating curve at left. With proper derating, the units can be operated down to -251C. Output P ow er % Derating Curve To operate the units over +501C at full load, a minimum forced air flow of 100 LFM is recommended A m bient Tem perature ( C) Peak Output Capability The maximum and peak current capabilities of all ADB05/10/16 models are given in the charts below. These specifications are defined as: Dual Output Models Maximum - The maximum continuous operating load of each output. On multiple output units, the max load cannot be drawn from each output at the same time. The total output load cannot exceed the rating for the whole unit. Peak - Single Output Models A D B 05S 03 Max. Current Voltage The peak output load can be drawn for less than 60 seconds at a duty cycle that is less than 10% Output Model Number Outputs (Vout 1 & Vout 2) Model Number P eak Current A D B 05D 05 "5.0 VDC "0.50A "0.57A A D B 05D 12 "12.0 VDC "0.23A "0.26A A D B 05D 15 "15.0 VDC "0.18A "0.20A A D B 10D 05 "5.0 VDC "1.00A "1.15A A D B 10D 12 "12.0 VDC "0.45A "0.51A A D B 10D 15 "15.0 VDC "0.35A "0.40A Voltage Max. Current P eak Current 3.3 VDC 1.33A 1.59A A D B 16D 05 "5.0 VDC "1.50A "1.72A "12.0 VDC "0.68A "0.78A "15.0 VDC "0.55A "0.63A A D B 05S 05 5.0 VDC 1.00A 1.20A A D B 16D 12 A D B 05S 12 12.0 VDC 0.45A 0.54A A D B 16D 15 A D B 05S 15 15.0 VDC 0.36A 0.43A A D B 10S 03 3.3 VDC 2.40A 2.88A A D B 10S 05 5.0 VDC 2.00A 2.44A A D B 10S 12 12.0 VDC 0.83A 1.00A A D B 10S 15 15.0 VDC 0.70A 0.84A A D B 10S 24 24.0 VDC 0.45A 0.54A A D B 10S 48 48.0 VDC 0.25A 0.30A Triple Output Models Model Number Output One (Vout 1) Output Tw o/Three (Vout 2/3) Voltage Max. Current P eak Current ADB10T305 +3.3 VDC +1.00A +1.15A "5.0 VDC "0.40A "0.46A ADB10T312 +3.3 VDC +1.00A +1.15A "12.0 VDC "0.25A "0.29A ADB10T512 +5.0 VDC +1.00A +1.15A "12.0 VDC "0.25A "0.28A ADB10T515 +5.0 VDC +1.00A +1.15A "15.0 VDC "0.20A "0.23A ADB16T305 +3.3 VDC +1.80A +2.0A "5.0 VDC "0.75A "0.86 "0.35 Voltage Max. Current P eak Current A D B 16S 03 3.3 VDC 3.70A 4.44A A D B 16S 05 5.0 VDC 3.00A 3.60A A D B 16S 12 12.0 VDC 1.35A 1.62A A D B 16S 15 15.0 VDC 1.10A 1.32A ADB16T312 +3.3 VDC +1.80A +2.0A "12.0 VDC "0.30A A D B 16S 24 24.0 VDC 0.70A 0.84A ADB16T512 +5.0 VDC +1.80A +2.0A "12.0 VDC "0.30A "0.34 0.42A ADB16T515 +5.0 VDC +1.80A +2.0A "15.0 VDC "0.24A "0.27 A D B 16S 48 48.0 VDC 0.35A Mechanical Configuration - AB05 Series 0.20 (5.0 0) All dimensions are typical in inches (mm) Weight: 3.77 Oz (107g) 0.69 (17.50) 0.69 (17.50) 0.16 (4.0 0) 1 3 2 0.04 (1.0 1) D ia. Top View 1.85 (47.00 ) Side View 2.28 (58.00 ) Bottom View Vou t A dju st 6 5 Pin Single Output Dual Output 1 AC-Ground AC-Ground 2 AC-Neutral AC-Neutral 3 AC-Line AC-Line 4 +Vout 1 +Vout 1 5 No Pin Common 6 -V out 1 -Vout 2 4 0.28 (7.0 0) P ow er G ood S ignal 0.77 (19.50) 0.40 (10.16 ) M in. 0.49 (12.50 ) 0.39 0.39 (10.00 ) (10.00 ) 1.77 (45.00) Mechanical Configuration - AB10 Series All dimensions are typical in inches (mm) Weight: 4.23 Oz (120g) 0.20 (5.00) Pin Single Output Dual Output Triple Output 0.16 (4.00) 1 2 3 0.04 (1.01) D ia. Top View 2.56 (65.00) 2.13 (54.00) Side View AC-Ground AC-Neutral AC-Neutral 3 AC-Line AC-Line AC-Line 4 +Vout 1 +Vout 1 +Vout 2 5 No Pin Common +Vout 1 6 -Vout 1 -Vout 2 Common 7 No Pin No Pin -V out 3 Single/Dual Output Triple O utput 6 0.36 (9.14) M in. AC-Ground AC-Neutral Bottom View 5 5 6 7 4 4 0.28 (7.00) 0.28 (7.00) 0.87 (22.00) AC-Ground Bottom View Vout A djust P ow e r G ood S ignal 1 2 0.69 (17.50) 0.69 (17.50) 0.49 (12.50) 0.49 (12.50) 0.39 0.39 (10.00) (10.00) 0.30 0.31 0.30 (7.50) (8.00) (7.50) 1.77 (45.00) 1.77 (45.00) Mechanical Configuration - AB16 Series 0.16 (4.10) All dimensions are typical in inches (mm) Weight: 5.11 Oz (145g) 0.78 (19.90) 0.16 (4.05) 2 1 3 0.04 (1.01) D ia. Top View 2.75 (69.90) Bottom View 2.43 (61.80) Side View Pin Single Output Dual Output Triple Output 0.78 (19.90) 1 AC-Ground AC-Ground AC-Ground 2 AC-Neutral AC-Neutral AC-Neutral 3 AC-Line AC-Line AC-Line 4 +Vout 1 +Vout 1 -Vout 3 5 No Pin Common +Vout 1 Common 6 Common -Vout 2 7 Remote On/Off Remote On/Off +Vout 2 8 No Pin No Pin Remote On/Off Bottom View Single/D ual Output Triple Output Vout A djust 7 P ow er G ood S ignal 6 4 5 0.16 (4.05) 0.93 (23.50) 0.24 (6.00) M in. 8 7 6 5 4 0.16 (4.05) 0.20 (5.15) 0.29 0.45 (7.40) (11.45) 0.45 (11.50) 1.89 (48.00) 0.20 (5.15) 0.30 0.39 0.39 0.39 (7.70) (10.00) (10.00) (10.00) 1.89 (48.00) Micr oP ower Dir ect ! TEL: (781) 344-8226 ! FAX: (781) 344-8481 ! E-Mail: sales@micropowerdirect.com ! WEB: www/micropowerdirect.com MicroP oPo Direct