Thyristors Surface Mount - 200V-600W > 2N6071A/B Series 2N6071A/B Series Pb Description Designed primarily for full-wave AC control applications, such as light dimmers, motor controls, heating controls and power supplies; or wherever full-wave silicon gate controlled solid-state devices are needed. Triac type thyristors switch from a blocking to a conducting state for either polarity of applied anode voltage with positive or negative gate triggering. Features * Sensitive Gate Triggering Uniquely Compatible for Direct Coupling to TTL, HTL, CMOS and Operational Amplifier Integrated Circuit Logic Functions * Gate Triggering: 4 Mode - 2N6071A, B; 2N6073A, B; 2N6075A, B * Blocking Voltages to 600 V * All Diffused and Glass Passivated Junctions for Greater Parameter Uniformity and Stability Pin Out * Small, Rugged, Thermopad Construction for Low Thermal Resistance, High Heat Dissipation and Durability REAR VIEW SHOW TAB 2 1 TO-225 CASE 077 STYLE 5 * Device Marking: Device Type, e.g., 2N6071A, Date Code Functional Diagram Additional Information Datasheet Resources Samples (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Maximum Ratings and Thermal Characteristics (TJ = 25C unless otherwise noted) Rating Symbol *Peak Repetitive Off-State Voltage (Note 1) (TJ = -40 to 110C, Sine Wave, 50 to 60 Hz, Gate Open) VDRM, 2N6071A,B VRRM Value 200 2N6073A,B 400 2N6075A,B 600 *On-State RMS Current (TC = 85C) Full Cycle Sine Wave 50 to 60 Hz Unit IT(RMS) 4.0 A ITSM 30 A I2t 3.7 A2s *Peak Gate Power (Pulse Width "1.0 s, TC = 85C) PGM 10 W *Average Gate Power (t = 8.3 ms, TC = 85C) PG(AV) 0.5 W *Peak Gate Voltage (Pulse Width "1.0 s, TC = 85C) VGM 5.0 V *Operating Junction Temperature Range TJ -40 to +110 C *Storage Temperature Range Tstg -40 to +150 C _ 8.0 in. lb. *Peak Non-repetitive Surge Current (One Full cycle, 60 Hz, TJ = +110C) Circuit Fusing Considerations (t = 8.3 ms) Mounting Torque (6-32 Screw) (Note 2) Stresses exceeding Maximum Ratings may damage the device. Maximum Ratings are stress ratings only. Functional operation above the Recommended Operating Conditions is not implied. Extended exposure to stresses above the Recommended Operating Conditions may affect device reliability. 1.VDRM and VRRM for all types can be applied on a continuous basis. Blocking voltages shall not be tested with a constant current source such that the voltage ratings of the devices are exceeded. 2.Torque rating applies with use of a compression washer. Mounting torque in excess of 6 in. lb. does not appreciably lower case-to-sink thermal resistance. Main terminal 2 and heatsink contact pad are common. Thermal Characteristics Rating Symbol Value Unit *Thermal Resistance, Junction to Case R8JC 3.5 C/W Thermal Resistance, Junction to Ambient (Note 1) R8JA 75 C/W TL 260 C Maximum Lead Temperature for Soldering Purposes, 1/8" from case for 10 seconds *Indicates JEDEC Registered Data.. (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Electrical Characteristics - OFF (TC = 25C unless otherwise noted; Electricals apply in both directions) Characteristic *Peak Repetitive Blocking Current (VD = VDRM = VRRM; Gate Open) TJ = 25C TJ = 110C Symbol Min Typ Max Unit IDRM, - - 10 A - - 2 mA IRRM Electrical Characteristics - ON (TC = 25C unless otherwise noted; Electricals apply in both directions) Characteristic Symbol Min Typ Max Unit C - - 2 V *Gate Trigger Voltage (Continuous DC), All Quadrants (Main Terminal Voltage = 12 Vdc, RL = 100 , TJ = -40 C) VGT - 1.4 2.5 V Gate Non- Trigger Voltage, All Quadrants (Main Terminal Voltage = 12 Vdc, RL = 100 , TJ = 110C) VGD .02 - - V - - 30 - - 15 - 1.5 - *Peak On-State Voltage (Note 3) (ITM = 6.0 A Peak) *Holding Current (Main Terminal Voltage = 12 Vdc, Gate Open, Initiating Current = 1 Adc) TJ = -40C TJ = 25C Turn-On Time (ITM = 14 Adc, IGT = 100 mAdc) IH tgt mA s QUADRANT (Maximum Value) Gate Trigger Current (Continuous DC) (Main Terminal Voltage = 12 Vdc, RL = 100 ) Type IGT @ TJ I mA II mA III mA IV mA 2N6071A +25C 5 5 5 10 2N6075A -40C 20 20 20 30 2N6071B +25C 3 3 3 5 -40C 15 15 15 20 Min Typ Max Unit - 5 10 V/s 2N6073A 2N6073B 2N6075B 3.Pulse Test: Pulse Width 2.0 ms, Duty Cycle 2%. *Indicates JEDEC Registered Data. Dynamic Characteristics Characteristic Critical Rate of Rise of Commutation Voltage @ VDRM, TJ = 85C, Gate Open, ITM = 5.7 A, Exponential Waveform, Commutating di/dt = 2.0 A/ms Symbol dv/dt(c) (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series SAMPLE APPLICATION: TTL-Sensitive Gate 4 Ampere Triac Triggers in Modes II and III 14 0V MC7400 4 7 VEE = 5.0 V + -V EE 510 2N6071A LOAD 115 VAC 60 Hz Trigger devices are recommended for gating on Triacs. They provide: 1.Consistent predictable turn-on points. 2.Simplified circuitry. 3.Fast turn-on time for cooler, more efficient and reliable operation. Voltage Current Characteristic of Triacs (Bidirectional Device) Symbol Parameter VDRM Peak Repetitive Forward Off State Voltage IDRM Peak Forward Blocking Current I I VRRM Peak Repetitive Reverse Off State Voltage IRRM Peak Reverse Blocking Current VTM Maximum On State Voltage IH I I Holding Current (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Sensitive Gate Logic Reference Firing Quadrant IC Logic Functions I II III IV TTL _ 2N6071A Series 2N6071A Series _ HTL _ 2N6071A Series 2N6071A Series _ CMOS (NAND) 2N6071B Series _ _ CMOS (Buffer) _ 2N6071B Series 2N6071B Series Operational Amplifier 2N6071A Series _ _ Zero Voltage Switch _ 2N6071A Series 2N6071A Series 2N6071B Series _ 2N6071A Series _ Quadrant Definitions for a Triac Quadrant II Quadrant I I Quadrant III Quadrant IV (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Ratings and Characteristic Curves Figure 1. Average Current Derating Figure 2. RMS Current Derating Figure 3. Power Dissipation Figure 4. Power Dissipation Figure 5. Typical Gate-Trigger Voltage Figure 6. Typical Gate-Trigger Current (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Figure 7. Maximum On-State Characteristics Figure 8. Typical Holding Current Figure 9. Maximum Allowable Surge Current Figure 10. Thermal Response (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17 Thyristors Surface Mount - 200V-600W > 2N6071A/B Series Dimensions Part Marking System -BU F C Q REAR VIEW SHOW TAB M -A- TO-225 CASE 077 STYLE 5 13 2 H 2 1 K J V G R 0.25 (0.010)BM A S M M Ordering Information D 2 PL 0.25 (0.010)BM A Dim Inches M M Max Min Max A 0.425 0.435 10.80 11.04 B 0.295 0.305 7.50 7.74 C 0.095 0.105 2.42 2.66 D 0.020 0.026 0.51 0.66 F 0.115 0.130 2.93 3.30 0.094 BSC 2.39 BSC H 0.050 0.095 1.27 2.41 J 0.015 0.025 0.39 0.63 K 0.575 0.655 14.61 16.63 M Package 2N6071A TO-225 2N6071AG TO-225 (Pb-Free) 2N6071AT TO-225 2N6071ATG TO-225 (Pb-Free) 2N6071B TO-225 2N6071BG TO-225 (Pb-Free) 2N6071BT TO-225 2N6071BTG TO-225 (Pb-Free) 2N6073A TO-225 2N6073AG TO-225 (Pb-Free) 2N6073B TO-225 2N6073BG TO-225 (Pb-Free) 2N6075A TO-225 2N6075AG TO-225 (Pb-Free) 2N6075B TO-225 2N6075BG TO-225 (Pb-Free) Millimeters Min G Device 5 TYP 5 TYP Q 0.148 0.158 3.76 4.01 R 0.045 0.065 1.15 1.65 S 0.025 0.035 0.64 0.88 U 0.145 0.155 3.69 3.93 V 0.040 --- 1.02 --- 1. DIMENSIONING AND TOLERANCING PER ANSI Y14.5M, 1982. 2.CONTROLLING DIMENSION: INCH. 3.077-01 THRU -08 OBSOLETE, NEW STANDARD 077-09. Disclaimer Notice - Information furnished is believed to be accurate and reliable. However, users should independently evaluate the suitability of and test each product selected for their own applications. Littelfuse products are not designed for, and may not be used in, all applications. Read complete Disclaimer Notice at: www.littelfuse.com/disclaimer-electronics. Shipping 500 Units / Box 50 Units / Tube 2000 Units / Box 500 Units / Box 50 Units / Tube 2000 Units / Box 500 Units / Box (c) 2017 Littelfuse, Inc. Specifications are subject to change without notice. Revised: 08/30/17