DS2000-3 - EMERSON�NETWORK POWER

Rev. 06.10.11_52

DS2000-3

1 of 4

Embedded Power for

Business-Critical Continuity

DS2000-3

2000 Watts 12 V

Distributed Power System

Special Features

•Activepowerfactorcorrection

•EN61000-3-2harmoniccompliance

•ActiveACinrushcontrol

•1UX3Uformfactor

•26.14W/in3

•+12Vdcoutput

•+3.3VdcStand-By

(5 V standby - consult factory)

•Nominimumloadrequired

•Hotplugoperation

•N+1redundant

•InternalOR’ingfets

•Activecurrentsharing

(10 - 100% load)

•Built-incoolingfans

(40mmx28mm)

•I2C communication interface bus

•PMBuscompliant

•EERPOMforFRUdata

•Red/Greenbi-colorLEDstatus

•Internalfanspeedcontrol

•INTEL,SSIStd.logictiming

•INTEL,SSIStd.FRUdataformat

•Oneyearwarranty

Distributed Power Bulk Front-End

Total Output Power: 2000 Watts

+12 Vdc main Output

+3.3 Vdc Stand-by Output

Wide Range Input voltage: 90 - 264 Vac

Electrical Specifications

Safety

Input

Inputrange 90-264Vac(widerange)

90-2641200Wload,nominal100Vac

180-2642000Wload,nominal200Vac

Frequency 47-63Hz,singlephaseAC

Inrushcurrent 55Amaximuminrushcurrent

Efficiency >89%typicalatfullload,highline

ConductedEMI FCCSubpartJEN55022ClassB

RadiatedEMI FCCSubpartJEN55022ClassB

Power factor 0.99typical

Leakagecurrent 1.40mA@240Vac

Holduptime 12 ms minimum

Output

MainDCvoltage +12V@164.2A 180-264Vac

+12V@100A 90-264Vac

Stand-By +3.3Vsb@9A(5V@5ATBA)

Adjustmentrange FactorySet,nopotadjustments

Regulation +12Vdc;±5%

+3.3Vsb;±5%

Overcurrent +12Vdc;latchesoffifovercurrentlastsover1second,

otherwiseitisautorecovery(Seeorderinginfonextpage)+3.3

Vsb,9Amax(sameas+12Vdc)

Overvoltage +12Vdc;13.2-14.4Vdc

+3.3Vsb;3.76-4.30Vdc

Undervoltage +12Vdc;9-10.8V(latchoff)

Turn-ondelay 2secondmax,5-300ms,MonotonicRise

+12VOutputRiseTime 5-50ms,MonotonicRise

•UL/cUL60950(ULRecognized)

•NEMKO+CBReportEN60950

•EN60950

•CEMark

•ChinaCCC

Rev. 06.10.11_52

DS2000-3

2 of 4

Embedded Power for

Business-Critical Continuity

OrderingInformation

ModelNumber NominalOutput

VoltageSetPoint

Set Point

Tolerance

Total

Regulation

Minimum

Current

Maximum

Current

OutputRipple

P/P Overcurrent Airflow

DS2000-3 12.2Vdc

3.3Vsb

±0.2%

±1%

±5%

161.5A

9.0A

120 mV

60mV

120-130%ofnominal

100 - 125% of nominal Standard

DS2000-3-001 12.2Vdc

3.3Vsb

±0.2%

±1%

±5%

161.5A**

9.0A

120 mV

60mV

120-130%ofnominal

100 - 125% of nominal Reverse

*Overcurrentlatchesoffifovercurrentlastsover1second,otherwiseitisautorecovery.

*For5Vsb,consultmarketing.

**Deratesperbelowcurve(-001)reverseair

LogicControl

PS_SEATED TTLlogicLOWifpowersupplyisseatedintosystemconnector.Thisisashortpin.AlogicHIGHifthePSU

isremoved.

PWRGOOD ActiveTTLLOWwhenoutputiswithinregulationlimits.

ACOK ALOWlogicleveliftheinputvoltageiswithinallowablelimits.ATTLlogicHIGHlevel,anda2mSearly

warningsignalbefore12.0VDCoutputlossofregulation.

PS_INHIBIT/PS_KILL ThissignalisconnectedtoashortpinonthePSU.

Whenleftopenpowersupplyoperationwillbeinhibited.Whenthepowersupplyisinsertedintothe

system,thispinwillbepulllowbythesystemandturnthepowersupplyononlyafterallotherpower

supplypinshaveseated.

Operatingtemperature -10 °C to 50 °C

Storagetemperature -40°Cto+85°CAltitude,operating10,000ft

Electromagnetic

susceptibility/Inputtransients

-EN61000-3-2,-3-3

-EN61000-4-2,4.3,4-4,-4-5,4-11Level

-EN55024:1998

RoHS&lead-freecompliant(notantalumcaps)

Humidity 20to90%RH,non-condensing

Shockandvibration SpecificationscomplieswithAstecStd.Specifications,Q3205

MTBF(Demonstrated) 500KHrsatfullload,40°C

EnvironmentalSpecifications

DS2000-3-001 Derating Curve

500

1000

1500

2000

2500

-10 -5 0 5 10 15 20 25 30 35 40 45 50

Operating Temperature (°C)

Output Power (W)

Low Line (90 Vac) High Line (180 Vac)

Rev. 06.10.11_52

DS2000-3

3 of 4

Embedded Power for

Business-Critical Continuity

Condition LED Status

+3V3SB-ON;+12VOUT-OFF;ACPRESENT BlinkingGreen

+3V3SB-ON,+12VOUT-ON SolidGreen

+12V_OCP,+12V_UVP,+48OVP BlinkingRed

FAN_FAULT,OTP,3V3OCP/UVP SolidRed

MechanicalDrawing

295.7 ± 1

(3X) 261.7

Programming Holes

292.1 ± 1

220.1

325.2

40370111360

Handle

40 ± 0.8

EMI Gasket

Laird Technologies (SEA) PTE

S3700-0021-00

EMI Gasket

Laird Technologies (SEA) PTE

S3700-0021-00

(3X) EMI Gasket

Laird Technologies (SEA) PTE

S3700-0021-00

Latch

AIRFLOW DIRECTION

3.2

106.7 ± 0.8

13.7 ± 0.8

99.1 ± 0.8

OUTPUT CONNECTOR

MOLEX 45985-1462

16.3 ± 0.8

220.1

325.2

100.2

72.2

GREEN

WAVE LENGTH: 565

YELLOW

WAVE LENGTH: 590

AC INLET

LABEL

ORIENTATION

THIS SIDE UP

Rev. 06.10.11_52

DS2000-3

4 of 4

Embedded Power for

Business-Critical Continuity

DCOutputConnectorPinout/Functions

UnitConnector;MolexBlade,(LPHSeries)45985-xxx

MatingConnector;MolexBlade,(LPHSeries)SD-45984-1462

NO OF SIGNALS

OPTIONAL

SEE CHART

TOP ROW

BOTTOM ROW

A17

PB1PB2 PB3PB4 PB5

TOP ROW

BOTTOM ROW

OPTIONAL PEGS

OPTIONAL GUIDES

Mating Connector - Molex p/n: 45984-1462

SignalPinA1BottomLeft

SignalPinA17TopLeft

SignalDescriptions

Americas

5810VanAllenWay

Carlsbad,CA92008

USA

Telephone:+17609304600

Facsimile: +17609300698

Europe (UK)

WaterfrontBusinessPark

MerryHill,Dudley

WestMidlands,DY51LX

UnitedKingdom

Telephone:+44(0)1384842211

Facsimile: +44(0)1384843355

Asia (HK)

14/F,LuPlaza

2WingYipStreet

KwunTong,Kowloon

HongKong

Telephone:+85221763333

Facsimile: +85221763888

Forglobalcontact,visit:

www.Emerson.com/EmbeddedPower

techsupport.embeddedpower

@emerson.com

Whileeveryprecautionhasbeentakentoensure

accuracyandcompletenessinthisliterature,Emerson

NetworkPowerassumesnoresponsibility,anddisclaims

allliabilityfordamagesresultingfromuseofthis

informationorforanyerrorsoromissions.

EmersonNetworkPowerandtheEmerson

NetworkPowerlogoaretrademarksand

servicemarksofEmersonElectricCo.

EmersonNetworkPower.com

EmbeddedComputing

Embedded Power

Monitoring

OutsidePlant

PowerSwitching&Controls

PrecisionCooling

Racks&IntegratedCabinets

Services

SurgeProtection

Emerson Network Power.

Thegloballeaderinenabling

business-criticalcontinuity.

ACPower

Connectivity

DC Power

*SupportsI2Cstandardmode(100kHz)only

SignalPin

#Comp Side

TopRow

Signal

Function

Signal

Description

SignalPin

#Solder Side

BottomRow

Signal

Function

Signal

Description

A17 3.3VSenseRTN 3.3VSenRtn A1 SPARE

A18 ACOK# ACinputpresent A2 SPARE

A19 A0 I2C address bit 0 A3 #ALERT

A20 A2 I2C address bit 2 A4 A1 I2C address bit 1

A21 SCL* I2CClocksignal A5 SDA I2CDatasignal

A22 PWOK# PwrOKoutput A6 PRESENT# Power supply present

A23 12LS 12Vloadsharebus A7 PSON# Power enable input

A24 +12VRSRtn +12VRmtSenRtn A8 +12VRS +12VRemoteSense

A25 3.3vsb Stand-By A9 3.3vsb Stand-By

A26 3.3vsb Stand-By A10 3.3vsb Stand-By

A27 3.3vsb Stand-By A11 3.3vsb Stand-By

A28 3.3vsb Stand-By A12 3.3vsb Stand-By

A29 3.3vsbRtn Stand-By return A13 3.3vsbRtn Stand-By return

A30 3.3vsbRtn Stand-By return A14 3.3vsbRtn Stand-By return

A31 3.3vsbRtn Stand-By return A15 3.3vsbRtn Stand-By return

A32 3.3vsbRtn Stand-By return A16 3.3vsbRtn Stand-By return

Power Blade Power Blade

PB1Top +12vdc MainOutput PB1 Bottom +12vdc MainOutput

PB2Top +12vdc MainOutput PB2 Bottom +12vdc MainOutput

PB3Top +12vdc MainOutput PB3Bottom +12vdcRtn MainOutput

PB4Top +12vdcRtn MainOutput PB4Bottom +12vdcRtn MainOutput

PB5Top +12vdcRtn MainOutput PB5 Bottom +12vdcRtn MainOutput