TDE1767, A TDE1787, A INTERFACE CIRCUIT (RELAY AND LAMP-DRIVER) OPEN GROUND PROTECTION HIGH OUTPUT CURRENT ADJUSTABLE SHORT-CIRCUIT PROTECTION INTERNAL THERMAL PROTECTION WITH EXTERNAL RESET LARGE SUPPLY VOLTAGE RANGE ALARM OUTPUT INPUT VOLTAGE CAN BE HIGHER THAN VCC OUTPUT VOLTAGE CAN BE LOWER THAN GROUND (VCC - VO VCC[max]) DESCRIPTION The TDE1767, A/TDE1787, A are a monolithic amplifiers designed for high current and high voltage applications, specifically to drive lamps, relays, stepping motors. The devices are assentially blow-out proof. The output is prois protected from short-circuits with the positive supply or drive. In addition thermal shut down is provited to keep the IC from overheathing. If internal dissipation becomes too high, the driver will shut down to prevent excessive heating. The output stays null after the overheating is off, if the reset input is low. If high the output will alternatively switch-on and off until the overload is removed. The devices operates over a wide range voltages from standard 15 V operational amplifier supplies to the single +6V or +48V used for industrial electric systems. Input voltages can be higher than in the VCC. An alarm output suitable for driving a LED is provited. This LED, normally on (if referred to ground), will die out or flash during an overload depending on the state of the reset input. The output is low in open ground conditions. Minidip ORDERING NUMBERS : TDE1767 DP TDE1767 ADP TDE1787 DP TDE1787 ADP PIN CONNECTION (top view) THERMAL DATA Symbol Parameter Value Unit R th (j - c) Maximum Junction-case Thermal Resistance 30 C/W Rth (j - a) Maximum Junction-ambient Thermal Resistence 80 C/W * Devices bonded on a 40 cm2 glass-epoxy printed circuit 0.15 cm thick with 4 cm2 of copper. March 1993 1/10 TDE1767,A-TDE1787,A ABSOLUTE MAXIMUM RATINGS Symbol Parameter TDE1767A/TDE1787A TDE1767/TDE1787 Unit VCC Supply Voltage 60 50 V VID Input Differential Voltage 60 50 V Vl Input Voltage - 10 to + 60 - 10 to + 50 V IO Output Current 1.3 1.2 A Reset Input Voltage - 0.5 to + 60 - 0.5 to + 50 V IOA Alarm Output Current - 10 to + 20 - 10 to + 20 mA Vl(reset) Ptot Power Dissipation Toper Operating Ambient Temperature Range - 25 to + 85 - 25 to + 85 C T stg Storage Temperature Range - 65 to + 150 - 65 to + 150 C SCHEMATIC DIAGRAM EQUIVALENT SCHEMATIC 2/10 Internally Limited mW TDE1767,A-TDE1787,A Figure 1. ELECTRICAL CHARACTERISTICS (Unless otherwise specified) TDE1767A: - 25 C Tamb + 85C, + 6 V VCC + 55 V, Io 500 mA, Tj + 150C TDE1767: - 25 C Tamb + 85C, + 6 V VCC + 45 V, I o 500 mA, Tj + 150C TDE1787A: - 25 C Tamb + 85C, + 6 V VCC + 55 V, Io 300 mA, Tj + 150C TDE1767A: - 25 C Tamb + 85C, + 6 V VCC + 45 V, Io 300 mA, Tj + 150C Symbol Parameter VIO Input Offset Voltage - (note 1) ICC Power Supply Current (measured on pin 4) Min. Typ. Max. 2 50 Unit mV mA Output High (Tamb = + 25 C) - 5.8 8 Output High (VCC = VCC(max), Tj = + 150 C) - 5 7 Output Low (VCC = VCC(max), Tamb = + 25 C) - 1.5 4 - 15 100 A Common-mode Input Voltage Range TDE1787A, TDE1767A TDE1787, TDE1767 1 1 - 60 45 V Vl Input Voltage Range (Vref + 1 V) (figure 1, note 2) TDE1787A, TDE1767A TDE1787, TDE1767 0 0 - 60 45 V ISC Short-circuit Output Current (VCC = + 35 V, t = 10 ms) IIB VCM Input Bias Current RSC = 0.22 RSC = 0.33 mA TDE1767A TDE1787A Vsense Output Limit Sense Voltage : VO = VCC - 2 V, t = 10ms (VO = VCC - 2 V) : V O = 0 V, t = 10 ms VO(sat) Output Saturation Voltage (output high Vl+ - Vl- 50 mV, RSC = 0, VCC = + 30 V) Tj= + 25C Tj = + 150 C TDE1787A, TDE1767A TDE1787, TDE1767 TDE1787A, TDE1767A TDE1787, TDE1767 - 700 380 - 130 120 150 140 170 165 mV V - 1 1 1.1 1.1 1.1 1.2 1.2 1.3 - - 100 A IOL Output Leakage Current (output low) IA Available Alarm Output Current Output Source Current (VAH = VCC - 2.5 V) Output Slnk Current (in thermal shut-down) VA = 1.4 V -4 5 -5 10 - Reset Input Current - 2 40 Reset Threshold - 1.4 - V Output Leakage Current (open ground) - 10 - A Ireset Vth (reset) - mA A Notes: 1. The offset voltage given is the maximum value of different input voltage reguired to drive the output voltage whitin 2 V of the ground or the supply voltage. 2. Input voltage range is indipendent of the supply voltage. 3/10 TDE1767,A-TDE1787,A 4/10 Figure 2. PEAK SHORT-CIRCUIT vs LIMITING RESISTOR. Figure 3. AVAILABLE OUTPUT CURRENT vs LIMITING RESISTOR. Figure 4. POWER SUPPLY CURRENT (pin 4). Fig.ure 5. OUTPUT SATURATION VOLTAGE vs OUTPUT CURRENT. Figure 6. OUTPUT TRANSISTOR SAFE OPERATING AREA (pulsed) Figure 7. NORMAL OPERATING AREA (short circuit protected) TDE1767,A-TDE1787,A ALARM OUTPUT CAPABILITY CURRENT Figure 8. CURRENT SINKING. Figure 9. CURRENT SOURCING Figure 10. REPONSE TIME Figure 11. REPONSE TIME Figure 12 : Test Circuit. 5/10 TDE1767,A-TDE1787,A TYPICAL APPLICATION Figure 13. Open Load Detection. Figure 14. Driving Lamps, Relays, Etc... Figure 15. Common Reset. 6/10 TDE1767,A-TDE1787,A Figure 16. Parallel Driving of Loads Up to 1 A. USING ALARM OUTPUT Figure 17. Parallel Alarm Outputs. Figure 18. Led to VCC. Figure 19. Led to Ground. 7/10 TDE1767,A-TDE1787,A Figure 20. Interface between High oltage and Low Voltage System. Figure 21. Increasing Current Up to 10 A. 8/10 TDE1767,A-TDE1787,A MINIDIP PACKAGE MECHANICAL DATA mm DIM. MIN. A TYP. inch MAX. MIN. 3.32 TYP. MAX. 0.131 a1 0.51 0.020 B 1.15 1.65 0.045 0.065 b 0.356 0.55 0.014 0.022 b1 0.204 0.304 0.008 0.012 D E 10.92 7.95 9.75 0.430 0.313 0.384 e 2.54 0.100 e3 7.62 0.300 e4 7.62 0.300 F 6.6 0.260 I 5.08 0.200 L Z 3.18 3.81 1.52 0.125 0.150 0.060 9/10 TDE1767,A-TDE1787,A Information furnished is believed to be accurate and reliable. However, SGS-THOMSON Microelectronics assumes no responsibility for the consequences of use of such information nor for any infringement of patents or other rights of third parties which may result from its use. No license is granted by implication or otherwise under any patent or patent rights of SGS-THOMSON Microelectronics. Specifications mentioned in this publication are subject to change without notice. This publication supersedes and replaces all information previously supplied. SGS-THOMSON Microelectronics products are not authorized for use as critical components in life support devices or systems without express written approval of SGS-THOMSON Microelectronics. 1994 SGS-THOMSON Microelectronics - All Rights Reserved SGS-THOMSON Microelectronics GROUP OF COMPANIES Australia - Brazil - France - Germany - Hong Kong - Italy - Japan - Korea - Malaysia - Malta - Morocco - The Netherlands - Singapore Spain - Sweden - Switzerland - Taiwan - Thaliand - United Kingdom - U.S.A. 10/10