UNIVERTER AC-DC Converters,PFC-1000 Module 380V Output , 170~265Vdc Input TM World Most Advanced Ultra High Density AC-DC Converters with Unity Power Factor Correction. The Maximum Output Power Is 1000W with 380V Output Voltage MODEL SELECTION Size: 116.3mm x 60.45mm x 12.7mm (4.58in. x 2.38in. x 0.50in.) Model Name Vin(Vdc) Vout(Vdc) Io(Amps) Watts PFC-1000 170~265 380 0~2.7 1000 FEATURES Miniature 1000 Watts. UL & TUV approved. DESCRIPTION Meets New European EN55022 emissions when used UniVerter PFC is AC-DC converter which is accepted with EMI filter. 170-265Vac as input and 380Vdc of output. Power Factor Unity power factor. Correction meets low harmonic distortion requirements of High efficiency. IEC 1000-3-2 and the new European EN55022 emissions Active inrush limiting and short circuit protection. specification when used with EMI filter. UniVerter Very low harmonic distortion. modules utilize a boost converter incorporating a solid Auxiliary supply. state series switch for active inrush and short circuit Power fail warning via DC OK signal. current limiting. The modules provide over temperature Load Enable signal to control DC-DC converters. shut-down and automatic recovery. -40~100oC baseplate operation. SPECIFICATION ABSOLUTE MAXIMUM RATINGS: PARAMETER Input Voltage(+In to -In) Input Power with No Damage Input Frequency Power Factor Correction MIN TYP MAX UNITS 170 230 265 Vac 0 300 Vac 47 63 Hz @Full Load 0.95 Maximum Input Current 5.4 Arms Inrush Current 30 Apeak Storage Temperature Isolation (Input & Output to Case) Operating Temperature Soldering Temperature(Wave Solder) Soldering Temperature(Hand Solder) -55 +125 2500 -40 CONDITIONS o C Vdc +100 o C Baseplate 260 o C <5 Sec. 390 o C <7 Sec. http://www.acbel.com Released: 05-30-'02 i. Specifications subject to change without notice. ii. All illustrations are for reference only. UNIVERTER AC-DC Converters,PFC-1000 Module 380V Output , 170~265Vdc Input TM INPUT SPECIFICATIONS: PARAMETER Operation Input Voltage (Vi ) MIN TYP MAX UNITS 170 230 265 Vac CONDITIONS Derate Output Power Linearly Below 205Vac from 1000W At 205Vac to 750W At 170Vac Maximum Input Current (Ii,max ) 5.4A Arms 30 A Vi=205Vac to 265Vac Io=Io,max Inrush Limiting @Full Load 0.95 Power Factor Uo=0 Harmonic Distortion 5 % 63 Hz Conforming to IEC 1000-3-2 with Filter 47 Input Frequency OUTPUT SPECIFICATIONS: CONDITIONS MIN TYP MAX UNITS 375 380 385 V With No Load Start Line Regulation 1 2 % Vi=205Vac to 265V Load Regulation 1 2 % PARAMETER Output Voltage Set Point (Vo,set) Io=0A to 2.65A Output Ripple and Noise Voltage: Io=0A to 2.65A Bandwidth 5Hz to 20MHz @120Hz With Output Capacitor Peak to Peak Output Current Limit 2.8 25 Vp-p 3.3 A 440uF/450V When Over Current Occurs, Output Drops to 0V Switching Frequency Efficiency 130 KHz 94 % o @Tc=25 C Vin=230Vac Io=2.65A o @Tc=90 C Vin=230Vac % 91 o DC OK Signal(@25 C) Provides Power Fail Maximum Sink Current 115 mA Maximum Break Voltage 60 V Load Enable Signal (@25oC) Maximum Break Voltage Output Current Warning When Output Drops Below 355V Direct interface with Next Maximum Sink Current Auxiliary Supply Voltage Io=2.65A 13.2 14 115 mA 60 V Stage DC-DC Converter 14.8 V When Input Exists, the 10 mA Auxiliary Supply Works http://www.acbel.com i. Specifications subject to change without notice. ii. All illustrations are for reference only. UNIVERTER AC-DC Converters,PFC-1000 Module 380V Output , 170~265Vdc Input TM CONTROL SPECIFICATIONS: PARAMETER TYP MIN UNITS MAX CONDITIONS Sec 2 Turn-On Time Io = 0A Vo within +/-1% Vo,set With 440uF / 450V Output CAP. V 425 Output Over Voltage Clamp Over Temperature Shutdown 100 105 110 TYP MAX o C Auto Recovery ISOLATION SPECIFICATIONS: PARAMETER MIN CONDITIONS UNITS Input to Case 2500 Vdc Output To Case 2500 Vdc GENERAL SPECIFICATIONS: PARAMETER MIN TYP UNITS MAX CONDITIONS Safety UL,TUV o Thermal Resistance 3.3 MTBF 1.0 Mhrs Weight 225 g 4.6 x 2.4 x 0.5 in3 C/W Tc=40oC, Io=2.65 Vin=230Vac Size OUTLINE DRAWING I/O LABEL 18.8 +0.15 0 47.0 BAR CODE LABEL +0.15 0 1.0 39.4 29.2 22.9 12.7 17.8 0.1 14.0 17.0 27.7 24.6 117.0 http://www.acbel.com i. Specifications subject to change without notice. ii. All illustrations are for reference only. UNIVERTER AC-DC Converters,PFC-1000 Module 380V Output , 170~265Vdc Input TM POWER FACTOR CORRECTION VO LTAG E VO LTAG E CURRENT RMS Value 4.952 CURRENT RMS Value 6.897 POWER FACTOR V.S. LOAD Power Factor -- PFC 1000 1.000 POWER FACTOR 0.998 220VAC, 25 C 0.996 0.994 240VAC, 25 C 0.992 0.990 0.988 0 200 400 600 800 1000 POWER OUT, WAT TS EFFICIENCY Efficiency - 1000 EfficiencyPFC PFC 1000 95 25C Case EFFICIENCY, PERCENT 93 100 C Case 91 89 87 Vin = 220VAC 85 0 020 400 600 800 1000 OUTPUT POWER, WATTS http://www.acbel.com i. Specifications subject to change without notice. ii. All illustrations are for reference only.