PSB
chip type power shunt resistor
Rated
Terminal Part
Temperature
Resistance
Tolerance
Resistance
Range
Part
Designation
Operating
Temperature
Range
Power
Rating
T.C.R.
(ppm/°C)
Max.
applications and ratings
PSB 6W ±75 0.75mΩ, 1mΩ
New 12.5W ±100 0.2mΩ-65°C to +155°C+105°CF: ±1%
Derating Curve
environmental applications
% Rated Power
100
80
60
40
20
-60 -40 -20 0406080 100 140
105
20
Terminal Part Temperature
(°C)
0
-65
120
155
Performance Characteristics
Parameter
Requirement ∆ R ±%
Limit Typical Test Method
Overload (Short time)
0.2m: 35W for 5 seconds
Rated power x 2.5 for 5 seconds
Use our designated aluminum circuit board & heat sink
0.2mΩ: 1.0%
0.75mΩ, 1.0mΩ:
±0.5% ±0.1%
Resistance to Solder Heat 0.75m, 1m: 260°C ± 5°C, 10 seconds ± 1 second
0.2mΩ: 1.0%
0.75mΩ, 1.0mΩ:
±0.5% ±0.2%
Rapid Change
of Temperature
0.2m: -55°C (30 minutes), +125°C (30 minutes), 1,000 cycles
0.75m, 1.0m: -40°C (30 minutes), +125°C (30 minutes), 1,000 cycles
0.2mΩ: 1.0%
0.75mΩ, 1.0mΩ:
±0.5% ±0.1%
Moisture Resistance 85°C ± 2°C, 85% RH, 1000 hours, 10% Bias
0.2mΩ: 1.0%
0.75mΩ, 1.0mΩ:
±0.5% ±0.1%
Endurance at 105°C and Less
of Terminal Part Temperature Terminal part temperature: 105°C ± 2°C, 1000 hours, 1.5 hr ON,
0.5 hr OFF cycle. Use our designated aluminum circuit board
±1.0% ±0.1%
Low Temperature Exposure -65°C, 96 hours
0.2mΩ: 1.0%
0.75mΩ, 1.0mΩ:
±0.5% ±0.1%
High Temperature Exposure +155°C, 1,000 hours
±1% ±0.1%
T.C.R. +25°C/+100°C
Within specified
T.C.R. ––
For resistors operated at a terminal part temperature of described for each size
or above, a power rating shall be derated in accordance with the derating curve.
Please refer to “Introduction of the derating curve based on the terminal
part temperature” in the beginning of our catalog before use.
93
KOA Speer Electronics, Inc. • 199 Bolivar Drive • Bradford, PA 16701 • USA • 814-362-5536 • Fax: 814-362-8883 • www.koaspeer.com
Specifications given herein may be changed at any time without prior notice. Please confirm technical specifications before you order and/or use. 4/12/17
resistors